LOGIN
Login E-mail:
Password:

Apply for an account! »
Product Search
Bottom
 

MSDS 85611

85611: Parts Washer Fluid 5 Gal Sw-3 [1]
MSDS Last updated: 02/02/2009

            MATERIAL SAFETY DATA SHEET
                Chem Free Corporation
            8 Meca Way, Norcross, GA 30093
          Tel: (770) 564-5580 Fax: (770) 564-5533
                   www.chemfree.com


Smart Washer
The Bioremediating Parts Washer

SECTION 1.
Product Name: Ozzy-Juice® SW-3 Truck Degreasing Solution
Product Use: Degreasing Fluid for the Smart Washer system
Manufactured by:  Chem Free Corporation
                  8 Meca Way
                  Norcross, GA 30093
                  U.S.A.
24 H Emergency Response:  HEPACO (800) 888-7869

SECTION II.  INGREDIENTS AND HAZARDS
HAZARDOUS         %       CAS #      LD50 OF INGREDIENTS   LC 50 OF INGREDIENT
                         NUMBER       (SPECIES & ROUTE)      (SPECIES & ROUTE)
Non Hazardous    100       N/A             N/A                    N/A
proprietary
water based
degreaser all
ingredients are
listed on the TSCA
Chemical Substance
Inventory and on the
Domestic Substance List

SECTION III. HAZARDS IDENTIFICATION
UN Number: Not Required
Dangerous Goods Classification: Non Hazardous
HAZARD RATINGS  (NFPA/HMIS)
HEALTH          1     0 = least
                      1 = slight
FLAMMABILITY    0     2 = moderate
                      3 = high
REACTIVITY      0     4 = extreme

SECTION IV. PHYSICAL / CHEMICAL CHARACTERISTICS
PHYSICAL STATE:  Liquid            SOLUBILITY IN WATER: Soluble
BOILING POINT: 210 F/99 C          pH:  7.51
VAPOR DENSITY (AIR=1):  1.689
APPEARANCE AND ODOR:  Clear, low-odor fluid
SPECIFIC GRAVITY: 1.0182
VOC Content:  <5 g/L

SECTION V. FIRST AID MEASURES
EMERGENCY & FIRST AID PROCEDURES:
    EYES: It is unlikely that emergency treatment will be required: if adverse
    effects occur, rinse eyes with large amounts of water until irritation    
subsides. Seek medical attention if necessary .
    SKIN: Wash with soap and water.
    INGESTION: It is unlikely that emergency treatment will be required: if    
adverse effects occur, treat symptomatically and seek medical attention if    
necessary.
    INHALATION: It is unlikely that emergency treatment will be required: if
    adverse effects occur, remove to fresh air and observe. Seek medical    
attention if necessary.

SECTION VI. FIRE & EXPLOSION HAZARD DATA
FLAMMABILITY: None
MEANS OF EXTINCTION:  N/A
FLASH POINT: None > 200 F (Approx.)           METHOD USED: Open cup
FLAMMABLE LIMITS: N/A
UPPER: N/A
LOWER: N/A
SPECIAL FIRE FIGHTING PROCEDURES: None
UNUSUAL FIRE & EXPLOSION HAZARDS: None

SECTION VII. ACCIDENTAL RELEASE MEASURES
In the event that this material is released or spilled, it can be washed into
storm sewer with large quantities of water.

SECTION VIII. HANDLING, STORAGE & TRANSPORT INFORMATION
No special precautions are required. This product is not hazardous for storage
and transport according to the U.S. Department of Transportation Regulations.

SECTION IX. EXPOSURE CONTROLS
Exposure Limits: This product presents no health hazards to the user when used
according to label directions for its intended purposes.

SECTION X. PERSONAL PROTECTION
RESPIRATORY PROTECTION (Specify Type): Not required.
PROTECTIVE GLOVES: It is recommended that rubber gloves be worn when handling
                   any Industrial-use products.
EYE PROTECTION:    It is recommended that safety glasses be worn when handling  
                 any Industrial-use products.
OTHER / HYGIENIC PRACTICES: Always use good housekeeping procedures when using
                   any chemical product.

SECTION XI. STABILITY AND REACTIVITY DATA
REACTIVITY: Non reactive
STABILITY: Stable
HAZARDOUS POLYMERIZATION: Will not occur

SECTION XII. TOXICOLOGICAL PROPERTIES
ROUTES OF ENTRY: Skin, Eyes
EFFECTS OF ACUTE EXPOSURE: It is unlikely that exposure will require treatment
                 because product is considered a dermal non-irritant and a mild 
                ocular irritant.

HEALTH HAZARDS (Acute & Chronic): None
CARCINOGENICITY: None known
TETRATOGENICITY: None known

SECTION XIII. BIODEGRADABILITY AND ENVIRONMENTAL TOXICITY INFORMATION
BIODEGRADABILITY:       Biodegradable

TOXICITY INFORMATION:
             48 hours LC50 value in mg/L
Ceriodaphnia dubia 306.49 mg/L
Fathead Minnos 624.30 mg/L

SECTION XIV. DISPOSAL CONSIDERATIONS
WASTE DISPOSAL: Dispose of used fluid in accordance with Local, State and
Federal regulations.

SECTION XV. ADDITIONAL INFORMATION
Prepared by: Karen Graham                 Date: June, 10 2008

The information contained in this MSDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this MSDS shall be created or inferred by any statement in this MSDS. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this MSDS. The user is responsible for full compliance.

For more product information by email, click here

Imperial Supplies LLC does not provide services and products outside the United States

credit card logos