Start an Order |
|
|
|
| Start an Order |
|||
| Home > Products > Chemicals & Paint > MSDS Sheets > MSDS 4010 -- [Back] | |||
|
MSDS 4010 4010: Hand Cleaner-With Grit 1 Gal [1] (DISCONTINUED)MSDS Last updated: 09/11/2002
MATERIAL SAFETY DATA SHEET
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
MANUFACTURER'S NAME: LOCTITE CORPORATION
MANUFACTURER'S ADDRESS: 1001 TROUT BROOK CROSSING
CITY, STATE, ZIP: ROCKY HILL CT 06067
PHONE NUMBER: (860) 751-5100
EMERGENCY NUMBER: (CHEM TEL) 1-800-255-3924
DISTRIBUTOR'S NAME: IMPERIAL SUPPLIES LLC
DISTRIBUTOR'S ADDRESS: 789 PACKER DRIVE
CITY, STATE, ZIP: GREEN BAY, WI. 54307
PHONE NUMBER: 1-800-558-2808
Imperial Part # 4010
Product Name; Imperial ® Tough Scrub Hand Cleaner Pumice Formula 4010
Item No: 20772
Product Type; Industrial Hand cleaner
2. COMPOSITION, INFORMATION ON INGREDIENTS
Ingredients CAS No. %
--------------------------------------------------------------------------------
Water 7732-18-5 50-60
Distillates (petroleum),
Hydrotreated light 64742-47-8 27-32
Fatty acid soap 68132-50-3 4-9
PO/ED linear C6-12 Alcohol 68154-97-2 3-8
Pumice 1332-09-8 2-8
SILICA, QUARTZ 014808-60-7 0.1-1
Ingredients which have exposure limits
Exposure Limits (TWA) ACGIH OSHA OTHER
Ingredients (TLV) (PEL)
----------------------------------------------------------------------------
Distillates (petroleum),
Hydrotreated light None None 300ppm
Pumice 10 mg/m3 (Ihna1) 15 mg/m3 (Total) None
3 mg/m3 (Resp) 5 mg/m3 (Resp)
SILICA, QUARTZ 0.05 mg/m3 TWA 0.1 mg/m3 TWA None
Respirable dust Respirable dust
Exposure Limits (STEL) ACGIH OSHA
Ingredients (TLV) (PEL)
3. HAZARDS IDENTIFICATION
Toxicity:
Eye irritant. May irritate respiratory system upon frequent or prolonged use.
High concentrations may irritate eyes, nose and respiratory system and cause
central nervous system effects. Swallowing may cause gastrointestinal
irritation, nausea, vomiting, and diarrhea. Material vomited after ingestion
and aspirated into the lungs may cause bronchopneumonia or pulmonary edema,
which may be fatal. It has been suggested that mineral spirits may cause
kidney damage in laboratory animals.
Primary Routes of Entry;
Skin contact, ingestion, and inhalation.
Signs and Symptoms of
Exposure;
None under normal conditions of use. Overexposure may cause eye or
respiratory system irritation; headache, nausea, dizziness, weakness,
fatigue, unconsciousness; vomiting diarrhea; eye redness, tearing, blurred
vision.
Existing Conditions
Aggravated by Exposure:
Possibly skin conditions and kidney damage.
Literature Referenced Carcinogen
Ingredients Target Organ and Other Health Effects NIP IARC OSHA
Water NTO NO NO NO
Distillates (petroleum),
Hydrotreated light NTO NO NO NO
Fatty acid soap No Data NO NO NO
PO/EO linear C6-12,
Alcohol No Data NO NO NO
Pumice NTO NO NO NO
SILICA, QUARTZ LUN SOM YES 2A NO
Abbreviations
2A Probably carcinogenic to humans LUN Lung
NTO No Target Organs SOM Some evidence of carcinogenicity
4. FIRST AID MEASURES
Ingestion; Do not induce vomiting. Call physician immediately
Inhalation; Remove to fresh air. If symptoms persist, obtain medical
attention.
Skin Contact; Flush with water.
Eye Contact; Flush at least 15 minutes with water. Call physician immediately.
5. FIRE FIGHTING MEASURES
Flash Point;
More than 200 _F Method; Pensky-Martens Closed Cup Recommended
Extinguishing Agents;
Carbon dioxide, chemical powder
Special Firefighting
Procedures;
Not available
Hazardous Products
Formed by Fire or
Thermal Decomp;
Irritating organic vapors
Unusual Fire or
Explosion Hazards;
None
Explosive Limits;
(% by volume in air) Lower Not available
(% by volume in air) Upper Not available
6. ACCIDENTAL RELEASE MEASURES
Steps to be taken in case of
spill or leak; Rinse away with water or wipe up with a towel.
7. HANDLING AND STORAGE
Safe Storage;
Hand cleaner should be stored between 40_F and 100_F (Contact Loctite
Customer Service 1-800-243-4874 for shelf life information)
Handling:
Follow all general safety precautions. Keep away from children.
8. EXPOSURE CONTROLS, PERSONAL PROTECTION
Eyes;
Not normally needed, but safety glasses offer increased protection.
Skin;
None normally needed.
Ventilation;
Local ventilation may be necessary if exposure is prolonged or vapor
concentrations are high.
Respiratory;
Not available
See Section 2 for Exposure Limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance; White, viscous liquid with scrubber particles.
Odor; Pleasant
Boiling Point; Not Available
pH; 7.5 - 8.5
Solubility in Water; Soluble
Specific Gravity; 0.94
Volatile Organic Compound
(EPA Method 24) 29.0%; 273 grams per liter of material
Vapor Pressure; Not available
Vapor Density; Not available
Evaporation Rate
(Ether = 1) Not available
10. STABILITY AND REACTIVITY
Stability; Stable
Hazardous Polymerization; Will not occur
Incompatibility; None
Conditions to Avoid; Not available
Hazardous Decomposition;
Products (non-thermal); None
11. TOXICOLOGICAL INFORMATION
Oral LD50 more than 5000 mg/kg
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended methods of
Disposal;
Dispose of uncontaminated material through sewage system with permission of
the authority responsible for that system. Follow EPA and local regulations.
EPA Hazardous Waste
Number;
NH - Not a RCRA Hazardous Waste Material
14. TRANSPORTATION INFORMATION
DOT (49 CFR 172)
Domestic Ground Transport
Proper Shipping Name; Unrestricted
Hazard Class or Division; Unrestricted
Identification Number; None
Marine Pollutant; None
IATA
Proper Shipping Name; Unrestricted
Class or Division; Unrestricted
UN or ID Number; None
15. REGULATORY INFORMATION
CA Proposition 65;
No California Prop 65 chemicals are known to be present at or above the No
Significant Risk level.
16. OTHER INFORMATION
Estimated NFPA ® Code;
Health Hazard; 1
Fire Hazard; 1
Reactivity Hazard; 0
Specific Hazard; Does not apply
Estimated HMIS ® Code;
Health Hazard; 1
Flammability Hazard; 1
Reactivity Hazard; 0
Personal Protection; See Section 8.
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Prepared By; Stephen Repetto
Title; Research Chemist - Health & Regulatory Affairs
Company; Loctite Corp. 1001 Tr Br Cr, Rocky Hill CT 06067
(24hr.) Phone; (860) 571-5100
Revision Date; June 14, 2002 Revision; 0025
The information contained in this MSDS was obtained from current and reliable sources, however, the data is provided without any warrenty, expressed or implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of Imperial Supplies LLC, Imperial will not be responsible for loss, injury, or expense arising out of the products improper use. No warranty, expressed or inferred, regarding the product described in this MSDS shall be created or inferred by any statement in this MSDS. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this MSDS. The user is responsible for full compliance. For more product information by email, click here Imperial Supplies LLC does not provide services and products outside the United States |
